workability of quarry dust in concrete by slump cone

workability quarry dust in concrete mix

dust at an interval of 5%, 10%, 15%, 20% and 25%. Mix details of concrete designed using Quarry dust. proportions for M20 concrete is prepared with reference to IS: Quarry dust is used an alternative for natural sand is collected 10262-2009 and IS: 456-2000 for the study of workability. from nearby quarry.

Read More+

Strength and Workability Properties of Concrete Replaced ...

2019-7-1 · Quarry dust replacing fine aggregates in M30 grade concrete Table2: Slump values with various proportions of GGBS replacing cement in M30 grade concrete S.no GGBS content slump 1 0% 96 2 10% 97 3 20% 98 4 30% 99 0 10 20 30 40 50 60 70 80 90 100 S l u m p 0% 20% 40% 60% 80% 100% Quarry dust Fig 1: slump values when replacement of sand by quarry ...

Read More+

Analysis of Concrete Made from Quarry Dust

2019-7-1 · considerable amount of quarry dust is composed. In this analysis, the experiment work is performed by using cement, fine aggregate, coarse aggregate, quarry dust. The examples were casted for M25 grade of concrete by supplanting the cement 0%, 5%, 10%, 15% and 20% by quarry dust and tested for workability by slump test,

Read More+

(PDF) Compressive Strength by

The study has conducted to determine the workability and compressive strength of the self –compacting concrete. The sand has replaced with quarry dust with the proportion of 10, 20, 30 and 40% ...

Read More+

Use of Quarry Fine as Partial Replacement of Concrete as

2014-10-10 · Concrete with quarry dust as fine aggregate In a study in Thailand by Khamput [11] on the compressive ... with a specific gravity of 2.59. workability of concrete admixture. 3) Coarse aggregate Crushed granite coarse aggregate conforming to IS: 383 ... homogeneously Slump cone test was taken to determine the Metal molds, in the form

Read More+

DEVELOPMENT OF HIGH PERFORMANCE CONCRETE

PCI/FHWB/FIB International Symposium on High Performance Concrete September 25-27, 2000 176 TEST RESULTS AND DISCUSSION Workability The workability was measured in respect of slump, slump-flow and ...

Read More+

(PDF) Improved Concrete Properties Using Quarry

VII. APPLICATIONS1) The quarry dust is widely used in construction industry. 2) Quarry dust is used as a fine aggregate in Concrete for paving blocks of good permeability capacity and high grade concrete productions. 3) Quarry dust gives better workability and strength when it is mixed with the ingredients like fly ash, in concrete. VIII.

Read More+

Effect of Quarry Dust on High Performance Concrete

2017-2-2 · Keywords - High performance Concrete, Quarry dust, Strength, Workability, Mechanical properties. 1.0 INTRODUCTION Concrete is a widely used material in the world. Based on global usage, it is placed at second position after water. Fine aggregate is an essential component of concrete

Read More+

(PDF) Study on Performance of Quarry Dust

The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%, 40%, 60%, 80% partial replacement of ...

Read More+

Use of Quarry Dust to Replace Sand in Concrete – An ...

2017-3-30 · To determine consistency of concrete, Slump test was conducted with varying water content and a particular water cement ratio (w/c) which gives the slump of 60mm was selected from graph. The various w/c for different proportions of sand and quarry dust was presented in Table 2. Table 2: Workability of concrete ( slump 60mm)

Read More+

workability quarry dust in concrete mix

dust at an interval of 5%, 10%, 15%, 20% and 25%. Mix details of concrete designed using Quarry dust. proportions for M20 concrete is prepared with reference to IS: Quarry dust is used an alternative for natural sand is collected 10262-2009 and IS: 456-2000 for the study of workability. from nearby quarry.

Read More+

(PDF) USE OF QUARRY DUST AND IRON FILINGS IN

Determination of workability of concrete. ... recorded as the slump cone was removed from the concrete. ... Both river sand concrete and quarry dust concrete for the selected water/cement ratio ...

Read More+

An Innovative Method of Replacing River Sand by Quarry ...

2016-9-9 · quarry dust. as . replacement . for sand . has been su. p. por. t-ed in the pr. e. vious study (Manassa, 2010) [5] showing that up to 20% of sand has been effectively replaced by quarry dust in traditional concrete. Ilangovan et al. (2008) [9] reported that the strength of quarry rock dust concrete was comparably 10-12% more than that of

Read More+

Durability Properties of High Strength Self Compacting ...

2016-4-14 · compacting concrete by using silica fume, Quarry Dust and admixtures in concrete to certain proportions. This project presents the durability characteristics of high strength self-compacting concrete by partially replacing cement by and silica fume and fine aggregate by quarry dust

Read More+

Experimental Studies on Effect of Alccofine in Workability ...

2015-12-12 · Fresh Properties of Concrete Slump test was conducted using slump cone. Table 7 Fresh Properties of Concrete Specimen Slump(mm) Normal Concrete 80 0.10% SF 80 0.25% SF 70 0.50% SF 60 0.5% SF+05% AF 70 0.5% SF+10% AF 90 0.5% SF+15% AF 110 Figure 1 Fresh Property of Concrete (Slump Value in mm) Hardened Properties of concrete

Read More+

Research Paper RELATION BETWEEN WORKABILITY AND ...

2012-5-9 · Since the slump test is not suitable for the analysis of the fluidity of self-compacting concrete, the slump flow test is adopted. The testing apparatus consists of a normal slump cone and a steel plate with the dimensions of 900 × 900 mm. With this apparatus, the time for self-compacting concrete

Read More+

Comparing the Compressive Strengths of Concrete Made

Unfortunately, the effect of quarry dust content in aggregates on properties of fresh and hardened concrete are not well known (Tahir and Khaled, 1999). A huge amount of quarry dust produced during the crushing of quarry stones in the quarry industries is often considered as waste and is often used as landfills (Rashid, at el, 2013).

Read More+

Characteristic studies on the mechanical properties of ...

2015-9-9 · Quarry dust The basic tests on quarry dust were conducted as per IS-383-1987 and its specific gravity was around 1.95. Wet sieving of quarry dust through a 90 micron sieve was found to be 78% and the corresponding bulking value of quarry dust was 34.13%. Coarse aggregate replacement of sand with quarry dust of mortar cube (C

Read More+

Sagar Panchal1, Molly Mathew2 - IJSER

2016-9-9 · The measured values of conventional concrete and quarry dust replaced concrete with water cement ratio 0.44 such as Mix 1(0% replacement), Mix 2(10% replacement), Mix 3 (20% replacement), Mix 4(30% replacement), Mix 5(40% replacement), Mix 6(50% replacement) respectively. The variations of the slump value with quarry dust percentage

Read More+

Utilisation of high volumes of limestone quarry wastes

2007-10-1 · In conventional concrete, the introduction of high volumes of limestone quarry dust to concrete mixes is limited due to its high fineness. Its corporation in excess amounts to fresh concrete increases the water demand, which has negative effects on the properties of fresh (longer setting times) and hardened concrete (low strength due to increased capillary porosity and loss of interface ...

Read More+

workability quarry dust in concrete mix

dust at an interval of 5%, 10%, 15%, 20% and 25%. Mix details of concrete designed using Quarry dust. proportions for M20 concrete is prepared with reference to IS: Quarry dust is used an alternative for natural sand is collected 10262-2009 and IS: 456-2000 for the study of workability. from nearby quarry.

Read More+

Workability of Concrete - Tests & Factors Affecting ...

Workability of concrete is defined as the ease and homogeneity with which a freshly mixed concrete or mortar can be mixed, placed, compacted and finished. Strictly, it is the amount of useful internal work necessary to produce 100% compaction.

Read More+

PARTIAL REPLACEMENT OF SAND BY QUARRY DUST IN

2017-5-27 · sand by quarry dust in M20 and M25 grade of concrete. And to find out if Quarry dust is a suitable replacement of sand or not. From this experimental result it is obtained that the 40% of sand replaced by quarry dust in concrete gives the maximum strength and then the strength reduces from 50% replacement of sand. 2. MATERIAL TO BE USED

Read More+

Durability Properties of High Strength Self Compacting ...

2016-4-14 · compacting concrete by using silica fume, Quarry Dust and admixtures in concrete to certain proportions. This project presents the durability characteristics of high strength self-compacting concrete by partially replacing cement by and silica fume and fine aggregate by quarry dust

Read More+

Use of Quarry Fine as Partial Replacement of Concrete

This paper is part of a study investigating the structural characteristics of concrete using various combinations of lateritic sand and quarry dust as complete

Read More+

Experimental Studies on Effect of Alccofine in Workability ...

2015-12-12 · Fresh Properties of Concrete Slump test was conducted using slump cone. Table 7 Fresh Properties of Concrete Specimen Slump(mm) Normal Concrete 80 0.10% SF 80 0.25% SF 70 0.50% SF 60 0.5% SF+05% AF 70 0.5% SF+10% AF 90 0.5% SF+15% AF 110 Figure 1 Fresh Property of Concrete (Slump Value in mm) Hardened Properties of concrete

Read More+

quarry dust interlocking blocks ratio 13 water

quarry dust interlocking blocks ratio 1:3 water. Housing Building Materials in Uganda. New technologies such as interlocking stabilized soil blocks (ISSB) have not been . waste, etc. are mixed with either sand or stone quarry dust, along with cement and water. by mixing calcium hydroxide (lime) and pozzolana in the ratio of 1: 1.5 or 1: 2.

Read More+

Exploration of Properties of Concrete by Partial ...

2020-2-22 · Fresh concrete is defined as that concrete which can be moulded to any shape.The slump test is used for fresh concrete. WORKABILITY The workability of fresh concrete was determined by slump cone test. The test was done as per IS - 1199:1959 . Fig. Determination of Slump value of concrete. APPARATUS REQUIRED 1.

Read More+

Comparing the Compressive Strengths of Concrete Made

Unfortunately, the effect of quarry dust content in aggregates on properties of fresh and hardened concrete are not well known (Tahir and Khaled, 1999). A huge amount of quarry dust produced during the crushing of quarry stones in the quarry industries is often considered as waste and is often used as landfills (Rashid, at el, 2013).

Read More+

HIGH EARLY STRENGTH OF SELF-CONSOLIDATING

2018-4-3 · Slump flow test was conducted in accordance to BS EN 12350-8:2010 to determine the workability of concrete as shown in Figure 7. The cone is lifted and the diameter of the concrete after the flow has stopped is measured. The average diameter of the concrete circle is a measure for the filling ability of the concrete.

Read More+
<< Previous:Mobile Iron Ore Impact Crusher Price In Nigeria
>> Next:Willow Sbr Rubber Sheet